Tesla Model X (2019+) - Workshop Manual - Electrical Circuits

TESLA MODEL X (2019+) - SERVICE MANUAL - WIRING DIAGRAMS

- English Service Manual / Repair Manual and Wiring Diagrams for vehicles Tesla Model X from 2019.


CONTENTS:

SERVICE MANUAL

- 1st Generation Autopilot
- 2nd Generation Autopilot
- 3 Way Coolant Valve - Radiator Bypass (Remove and Replace)
- 4 Way Coolant Valve - Series/Parallel (Remove and Replace)
- 12V battery
- 40A Fuse - Front Junction Box (Remove and Replace)
- 200A Fuses - Wall Connector (Remove and Replace)
- 2016-2018 VIN Decoders
- A/C Desiccant Bag Replacement
- A/C Refrigerant Leak Detection
- A/C Refrigerant Recovery and Recharge (Remove and Replace)
- Abbreviations and Symbols
- ABS Modulator Assembly (Remove and Replace)
- Accelerator Assembly (Remove and Replace)
- Active Louver - Center (Remove and Replace)
- Active Spoiler Assembly (Remove and Install)
- Active Spoiler Assembly (Remove and Retrofit)
- Actuator - Defrost (Remove and Replace)
- Actuator - Driver's Temperature (Remove and Replace)
- Actuator - E Release - Door - Front - LH (Remove and Install)
- Actuator - Front Passenger's Temperature (Remove and Replace)
- Actuator - Headrest - 3rd Row Seat - LH (Remove and Replace)
- Actuator - Headrest - Driver's (Remove and Replace)
- Actuator - Inlet (Remove and Replace)
- Actuator - Latch - Hood - Primary (Remove and Replace)
- Actuator - Latch - Hood - Secondary (Remove and Replace)
- Actuator - Mode (Remove and Replace)
- Actuator - Recliner - 3rd Row Seat - LH (Remove and Replace)
- Actuator and Cable - Cinching (Remove and Replace)
- Adjust Fog Lights Using a Headlight Tester
- Adjust Headlights Using a Headlight Tester
- Adjust Headlights Using a Headlight Tester
- Adjust Headlights Using a Wall
- Adjust Headlights Using a Wall
- Air Bag - Driver's (Remove and Replace)
- Air Bag - Front Passenger's (Remove and Replace)
- Air Bag and Supplementary Restraint System (SRS) Precautions General Precautions
- Air Conditioning System Precautions General
- Air Line - Air Suspension - Compressor to Valve Block (Remove and Replace)
- Air Line - Air Suspension - Valve Block Exhaust (Remove and Replace)
- Air Outlet - Center Console (Remove and Replace)
- Air Spring Module - Front - LH (Remove and Replace)
- Air Spring Module - Front - RH (Remove and Replace)
- Air Spring Module - Rear - LH (Remove and Replace)
- Air Spring Module - Rear - RH (Remove and Replace)
- Air Suspension - Pressurize/Depressurize - Full System
- Air Suspension - Pressurize/Depressurize - One Air Spring
- Air Suspension Lines - Front (Remove and Replace)
- Air Suspension Lines - Rear (Remove and Replace)
- Alignment Check
- Antenna - Bluetooth (Remove and Replace)
- Antenna - GPS (Remove and Replace)
- Antenna - GSM - LH (Remove and Replace)
- Antenna - Passive Entry - Center Console (Remove and Replace)
- Antenna - Passive Entry - Front (Remove and Replace)
- Antenna - Passive Entry - Rear (Remove and Replace)
- Antenna - Passive Entry - Rocker - LH (Remove and Replace)
- Antenna - RF Filter - LH (Remove and Replace)
- Antenna - Satellite Radio (Remove and Replace)
- Antenna Amplifier - AM/FM and RKE (Remove and Replace)
- Antenna Amplifier - FM2 (Remove and Replace)
- Applique - B-Pillar - LH (Remove and Replace)
- Applique - C-Pillar - LH (Remove and Replace)
- Applique - Front Quarter - LH (Remove and Replace)
- Applique - Liftgate (Remove and Replace)
- Applique - Rear Door - Front - LH (Remove and Replace)
- Applique - Roof - Front (Remove and Replace)
- Applique - Roof - Rear (Remove and Replace)
- Applique - Spine - Center (Remove and Replace)
- Applique - Spoiler (Remove and Replace)
- Armrest Pads - Center Console - 1st Row (Remove and Replace)
- Assembly - Bin - Storage Center Compartment (Remove and Replace)
- Assembly - Cover - Footwell - Driver's (Remove and Replace)
- Assembly - Cover - Footwell - Passenger's (Remove and Replace)
- Assembly - Finisher - Instrument Panel - LH (Remove and Replace)
- Assembly - Finisher - Instrument Panel - RH (Remove and Install)
- Assembly - Finisher - Instrument Panel - RH (Remove and Replace)
- Assembly - Frame - Instrument Cluster (Remove and Replace)
- Assembly - Instrument Panel Lower - RH (Remove and Replace)
- Assembly - Instrument Panel Side Cover - LH (Remove and Replace)
- Assembly - Mesh Grille - Defrost (Remove and Replace)
- Assembly - Top Pad - Instrument Panel (Remove and Install)
- Assembly - Top Pad - Instrument Panel (Remove and Replace)
- Assembly - Underhood Apron - Front (Remove and Replace)
- Back Board – Seat Back – 2nd Row – LH (Bench Seat)
- Back Board – Seat Back – 2nd Row – RH (Bench Seat)
- Backup
- Badge - Ludicrous Speed (Retrofit)
- Base - Armrest - Center Console (Remove and Install)
- Base - Armrest - Center Console (Remove and Replace)
- Bash Plate - Front - Extrusion (Remove and Replace)
- Battery - Auxiliary - 12V (Remove and Replace)
- Battery Chiller (Remove and Replace)
- Battery Coolant Pump 1 (Remove and Replace)
- Battery Coolant Pump 2 (Remove and Replace)
- Bezel - Exterior Door Handle - Front - LH (Remove and Replace)
- Bezel - Exterior Door Handle - Rear - LH (Remove and Replace)
- Bleed
- Bleed or Flush Procedure - System (Remove and Replace)
- Bleed Procedure - One Caliper (Remove and Replace)
- Body Controls Overview
- Bracket - 2nd Row Floor Panel - Center (Without 2nd Row Bench Seats)
- Bracket - 2nd Row Floor Panel - LH (Without 2nd Row Bench Seats)
- Bracket - C-Pillar - Lower Zone - LH (Remove and Replace)
- Bracket - C-Pillar - Mid Zone - LH (Remove and Replace)
- Bracket - Headlight - Inner - LH (Remove and Replace)
- Bracket - Headlight - Outer - LH (Remove and Replace)
- Bracket - Headlight Support - LH (Remove and Replace)
- Bracket - License Plate - Front (Retrofit)
- Bracket - Rear Door Trim - Center - LH (Remove and Replace)
- Bracket - Rear Door Trim - Upper - Front - LH (Remove and Replace)
- Bracket - Rear Door Trim - Upper - Rear - LH (Remove and Replace)
- Brake Caliper - Front - LH (Remove and Replace)
- Brake Caliper - Rear - Brembo - LH (Remove and Replace)
- Brake Caliper - Rear - Park Brake - LH (Remove and Replace)
- Brake Caliper Pad Slides - Cleaning and Lubrication
- Brake Caliper Pad Slides and Parking Brake Calipers - Cleaning and Lubrication
- Brake Fluid
- Brake Fluid Check
- Brake Fluid Flush
- Brake Hose - Flexible - Front - LH (Remove and Replace)
- Brake Hose - Flexible - Rear - LH (Remove and Replace)
- Brake Lines - 2 Tube Bundle - Rear (Remove and Replace)
- Brake Lines - 4 Tube Bundle - ABS to Wheels (Remove and Replace)
- Brake Lines - Master Cylinder to ABS (Remove and Replace)
- Brake Lines - Master Cylinder to ABS (RHD) (Remove and Replace)
- Brake Pad Kit - Front (Remove and Replace)
- Brake Pad Kit - Rear - Brembo (Remove and Replace)
- Brake Pad Kit - Rear - Mando (Remove and Replace)
- Brake Pads - Burnishing
- Brake Pads - Park Brake - Burnishing
- Brake Pads - Park Brake - Set (Remove and Replace)
- Brake Pedal (Remove and Replace)
- Brake Rotor - Front - LH (Remove and Replace)
- Brake Rotor - Rear - LH (Remove and Replace)
- Brakes
- Bright Trim - Upper Grille (Remove and Replace)
- Brightwork - Upper - Front - LH (Remove and Replace)
- Brightwork - Upper - Rear - LH (Remove and Replace)
- Buckle Assembly - 1st Row - LH (Remove and Replace)
- Buckle Assembly - 2nd Row - Center (Without 2nd Row Bench Seats) (Remove and Replace)
- Buckle Assembly - 2nd Row - LH (Without 2nd Row Bench Seats) (Remove and Replace)
- Buckle Assembly - 3rd Row (Remove and Replace)
- Bumper Assembly - Front (Remove and Replace)
- Bumper Assembly - Rear (Remove and Replace)
- Cable - Flex Drive - Long - Front Seat Motor (Remove and Replace)
- Cable - Flex Drive - Short - Front Seat Motor (Remove and Replace)
- Cable - Latch - Hood - Primary (Remove and Replace)
- Cable - Latch - Hood - Secondary (Remove and Replace)
- Cable - Recliner - 3rd Row Seat - LH (Remove and Replace)
- Cable Assembly – Light – Trailer (Remove and Replace)
- Cage - Battery - Auxiliary - 12V (Remove and Replace)
- Calibration - Front Radar Sensor
- Camera - B-Pillar (Remove and Replace) Removal
- Camera - Forward Facing (Remove and Replace)
- Camera - Rear View (Remove and Replace)
- CAN Setup
- Carpet - 1st Row (Remove and Replace)
- Carpet - Trunk Floor (Remove and Replace)
- Carpet - Underhood Storage (Remove and Install)
- Carpet Assembly - Sliding - LH (Remove and Replace)
- Carrier - Grille - Front Upper (Remove and Replace)
- Carrier - Rocker Panel - LH (Remove and Replace)
- Carrier - Sensor - Ultrasonic - Rear Door - LH (Remove and Replace)
- Center Console - 2nd Row (Remove and Replace)
- Center Console - 2nd Row (Retrofit)
- Center Console Assembly (Remove and Install)
- Channel - Glass Run - Front - LH (Retrofit)
- Charge Port - Manual Release of Cable
- Charge Port (Remove and Replace)
- Charger (China) (Remove and Replace)
- Charger (Remove and Replace)
- Charging Precautions
- Chime - Liftgate (Remove and Replace)
- Chime - Rear Door - LH (Remove and Replace)
- Cinching Actuator - Door - Rear - LH (Remove and Replace)
- Cladding - Door - Front - LH (Remove and Replace)
- Cladding - Door - Rear - LH (Remove and Replace)
- Cladding - Door - Rear - Wheel Arch - LH (Remove and Replace)
- Clean and Lubricate Brake Calipers
- Cleaning components
- Closeout Extension - Center Console - LH (Remove and Replace)
- Closeout Panel - Door - Front - LH (Remove and Install)
- Closeout Panel - Door - Front - LH (Remove and Replace)
- Closeout Panel - Door - Rear - LH (Remove and Install)
- Closing Plate - Spine (Remove and Replace)
- Coax Cable - Side Repeater - Front - LH (Replace)
- Coax Cable - Side Repeater - Front - RH (Replace)
- Component Transfer
- Compressor - Air Suspension (Remove and Replace)
- Compressor (Remove and Replace)
- Condenser (Remove and Replace)
- Connect
- Control Arm - Upper - Front - LH (Remove and Replace)
- Control Arm - Upper - Front - RH (Remove and Replace)
- Control Arm Assembly - Rear - Lower - LH (Remove and Replace)
- Coolant Concentration
- Coolant Heater - Electric - Battery (Remove and Replace)
- Coolant Solutions
- Coolant System - Check and Fill
- Cooling Fan Module (Remove and Install)
- Cooling System - Drain and Refill
- Cooling System - Partial Refill and Bleed
- Cooling System - Vacuum Refill
- Correction Codes and FRTs
- Cover - Outer Side - Driver's Seat (Remove and Install)
- Cover - Outer Side - Driver's Seat (Remove and Replace)
- Cover - Seat Back - 2nd Row - LH (Without 2nd Row Bench Seats) (Remove and Replace)
- Cover - Seat Back - Driver's (Remove and Replace)
- Cross Car Beam (Remove and Replace)
- Crossmember - Front Trunk (Remove and Replace)
- Cup Holder - 2nd Row (Remove and Replace)
- Cup Holder - 3rd Row Seat (Remove and Replace)
- Curtain Air Bag - 2nd Row - LH (Remove and Replace)
- Curtain Air Bag - Driver's (Remove and Replace)
- DAS 1.0 and DAS 2.0
- DAS 2.5
- DCDC Converter (Remove and Replace)
- Debris or moisture in the A/C system
- De-Calibration
- Decor - Center Console - 2nd Row (Remove and Replace)
- Depressurize
- Depressurize
- Diffuser Panel - Rear (Remove and Replace)
- Discharges to water
- Disconnect 12V Power
- Dock Connector - Telephone - USB - Center Console (Remove and Replace)
- Door - Charge Port (Remove and Replace)
- Door Assembly - Front - LH (Remove and Install)
- Door Assembly - Front - LH (Remove and Replace)
- Door Assembly - Rear Lower - LH (Remove and Install)
- Door Assembly - Rear Upper - LH (Remove and Install)
- Door Glass - LH - Front - Adjust
- Door Glass - LH - Front (Remove and Replace)
- Door Glass - LH - Rear - Adjust
- Door Glass - LH - Rear (Remove and Replace)
- Door Glass - Rear - Upper - LH (Remove and Replace)
- Door Mirror Assembly - LH (Remove and Replace)
- Drain & Refill
- Drive Cycle Calibration - Forward Facing Camera
- Drive Shaft - 2nd Row Seat Motor - LH (Remove and Replace)
- Drive Unit - Rear - Large (Remove and Install)
- Drive Unit - Rear - Large (Remove and Replace)
- Drive Unit - Rear - Small (Remove and Install)
- Drive Unit - Rear - Small (Remove and Replace)
- Drive unit number
- Drop Link - Sway Bar - Rear - LH (Remove and Replace)
- Duct - Fascia - HVAC (Remove and Replace)
- Duct - HEPA Filter (Remove and Replace)
- Dye Injection
- ECU Box (Remove and Install)
- E-Fuse Module (Remove and Replace)
- Electrical
- Electrical connectors and harnesses
- Electrical Isolation
- Electrical Joint Compound
- Electrical Precautions General
- Electromechanical Brake Booster Assembly (Remove and Replace)
- Electromechanical Brake Booster Assembly (RHD) (Remove and Replace)
- Emissions to air
- Encapsulated and Patch bolts
- Environmental Precautions General
- EXV Valve (Remove and Replace)
- Face Level Vent - Driver's - Inner (Remove and Replace)
- Face Level Vent - Driver's - Outer (Remove and Replace)
- Face Level Vent - Front Passenger's - Inner (Remove and Replace)
- Face Level Vent - Front Passenger's - Outer (Remove and Replace)
- Fan - Condenser (Remove and Replace)
- Fascia Assembly - Front (Remove and Install)
- Fascia Assembly - Front (Remove and Replace)
- Fascia Assembly - Rear (Remove and Install)
- Fascia Assembly - Rear (Remove and Replace)
- Fascia Bracket - Center (Remove and Replace)
- Filter - Cabin (Remove and Replace)
- Filter - HEPA (Remove and Replace)
- Firmware Update
- Firmware Update - CHAdeMO Charging Adapter
- Firmware Update - Mobile Connector - 2nd Generation
- First aid measures
- Fixed Glass - Front Door - LH (Remove and Replace)
- Fixed Glass - Rear Door - LH (Remove and Replace)
- Flexible Pipes and Hoses General
- Floor Panel - 1st Row (Remove and Replace)
- Floor Panel - 2nd Row - Front (Remove and Replace)
- Floor Panel - 2nd Row - Middle (Remove and Install)
- Floor Panel - 2nd Row - Middle (Remove and Replace)
- Floor Panel - 2nd Row - Middle (Repair)
- Floor Panel - 2nd Row - Rear (Remove and Install)
- Floor Panel - 2nd Row - Rear (Remove and Replace)
- Floor Panel - 2nd Row - Rear (Repair)
- Fluid Capacities
- Fluids Air Conditioning
- Foam and Trim - Cushion - Driver's Seat (Remove and Replace)
- Fore/Aft Adjustment

AND MORE...


ELECTRICAL WIRING DIAGRAMS

WIRING DIAGRAMS
- Table of Contents - Model X
- 12V Outlets:2:12V Outlets-12V Outlets
- Air Suspension:5:Air Suspension-Air Suspension
- Audio, Base & Premium:7:Audio, Base & Premium-Audio, Base&Premium P1
- Audio, Base & Premium:7:Audio, Base & Premium-Audio, Base&Premium P2
- CAN ABS:3:CAN ABS-CAN ABS
- CAN Body FT:1:Body Fault Tolerant CAN Network-CAN Body FT
- CAN Body:4:Body CAN Network-CAN Body
- CAN Chassis:2:Chassis CAN Network-CAN Chassis
- CAN Falcon:3:Falcon Sensing-CAN Falcon
- CAN Powertrain:4:Powertrain CAN Network-CAN Powertrain
- CAN Thermal:3:CAN Thermal-CAN Thermal
- Chassis - Braking and Stability:6:Chassis - Braking and Stability-Chassis - Braking and Stability
- Chassis - Braking and Stability:6:Chassis - Braking and Stability-Chassis - Electronic Park Brake + Brake Pedal
- Diagnostics:3:Diagnostics-Diagnostics
- Door Controls - Front Actuators:2:Door Controls - Front Actuators-Door Controls - Front Actuators
- Door Controls - Left Front:6:Door Controls-Door Controls - Left Front
- Door Controls - Left Rear:3:Door Controls - LR-Door Controls - Left Rear General
- Door Controls - Left Rear:3:Door Controls - LR-Door Controls - Left Rear Latches
- Door Controls - Right Front:4:Door Controls-Door Controls - Right Front
- Door Controls - Right Rear:3:Door Controls - RR-Door Controls - Right Rear General
- Door Controls - Right Rear:3:Door Controls - RR-Door Controls - Right Rear Latches
- Drive Inverter:4:Drive Inverter-Drive Inverter
- Drive Inverter:4:Drive Inverter-Drive Inverter P2 - RHD
- Driver Assistance:7:Driver Assistance-Driver Assistance p1
- Driver Assistance:7:Driver Assistance-Driver Assistance p2
- Energy System - Charger Logic Connections:4:Energy System - Charger Logic Connections-Energy System - Charger Logic Connections
- Exterior Illumination Front:4:Exterior Illumination Front-Exterior Illumination Front
- Exterior Illumination Rear:1:Exterior Illumination Rear-Exterior Illumination Rear
- Falcon Doors:4:Falcon Doors (EM) + SNS CAN-Falcon Doors - Electric Left
- Falcon Doors:4:Falcon Doors (EM) + SNS CAN-Falcon Doors - Electric Right
- Falcon Doors:4:Falcon Doors (EM) + SNS CAN-Falcon Doors - Obstacle Sensors
- Falcon Doors:4:Falcon Doors (EM) + SNS CAN-Falcon Doors - Pinch Sensors
- Falcon Doors:4:Falcon Doors (EM) + SNS CAN-Falcon Doors - UltraSonics
- Front Seat Interface LHS:1:Front Seat Interface LHS-Front Seat Interface LHS
- Front Seat Interface RHS:1:Front Seat Interface RHS-Front Seat Interface RHS
- Grounding - A-Pillars:2:Grounding schematic for A-Pillar grounds-Grounding - A-Pillars
- Grounding - Frunk:6:Grounding Schematic Frunk-Grounding - Frunk
- Grounding - IP and Center:5:Grounding Schematic IP and Center-Grounding - IP and Center
- Grounding - IP and Center:5:Grounding Schematic IP and Center-Grounding - IP and Center 2
- Grounding - Rear Doors:1:Grounding Schematic Rear Doors - Rev2 Updated GNDs-Grounding - Rear Doors
- Grounding - Rear:3:Grounding Schematic Rear Corners and Liftgate-Grounding - Rear
- Hatch Front Actuators/Sensors:2:Hatch Front Actuators / Sensors (DV2)-Hatch Front Actuators/Sensors
- Hatch Rear Actuators/Sensors:5:Hatch Rear Actuators/Sensors-Hatch Rear Actuators/Sensors
- High Voltage Interlock (HVIL):2:High Voltage Interlock (HVIL)-High Voltage Interlock (HVIL)
- Horn and Passive Entry / Security:2:Horn and Passive Entry / Security-Horn and Passive Entry / Security
- Horn and Passive Entry / Security:2:Horn and Passive Entry / Security-Horn and Passive Entry / Security p2
- HVAC - Cabin Climate and Rear Defrost:5:HVAC Cabin Climate and Rear Defrost-HVAC - Cabin Climate and Rear Defrost
- HVAC - Powertrain Cooling - Components:6:HVAC - Powertrain Cooling - Components-HVAC - Powertrain Cooling Components
- HVAC - Powertrain Cooling - Coolant Cycle:4:HVAC - Powertrain Cooling - Coolant Cycle-HVAC - Powertrain Cooling - Coolant Cycle
- Instrument Cluster / LIN:5:Instrument Cluster / LIN / Homelink-Instrument Cluster / LIN
- Interior Illumination Maplights:1:Interior Illumination Maplights-Interior Illumination Maplights
- Mirrors - Center and Side:2:Mirrors - Center and Side-Mirrors - Center and Side
- Parking Aids:6:Parking Aids-Parking Aids
- Passive Restraints - IP and Front:2:Passive Restraints - IP and Front-Passive Restraints - IP and Front
- Passive Restraints:3:Passive Restraints-Passive Restraints
- Passive Restraints:3:Passive Restraints-Passive Restraints p2
- Power Distribution - Aux:2:Aux Fuse Box-Power Distribution - Aux
- Power Distribution - Cabin:5:Cabin Junction Box-Power Distribution - Cabin 1/3
- Power Distribution - Cabin:5:Cabin Junction Box-Power Distribution - Cabin 2/3
- Power Distribution - Cabin:5:Cabin Junction Box-Power Distribution - Cabin 3/3
- Power Distribution - E-Fuse:1:E-Fuse-Power Distribution - E-Fuse
- Power Distribution - Frunk:6:Frunk Junction Box-Power Distribution - Frunk 1/2
- Power Distribution - Frunk:6:Frunk Junction Box-Power Distribution - Frunk 2/2
- Rear Seat Interface:3:Rear Seat Interface-Rear Seat Interface
- Rear Seat Interface:3:Rear Seat Interface-Rear Seat Interface P2 - Monopost Seats
- Rear Seat Interface:3:Rear Seat Interface-Rear Seat Interface P3 - 60/40 fold
- RF Cables:2:RF Cables-RF Cables
- Steering:4:Steering Wheel Controls / Power Steering-Steering
- Trailer Systems:2:Trailer Systems-Trailer Systems
- Wiper/Washer and Rain Sensor:5:Wiper/Washer and HVAC Sensor-Wiper/Washer and HVAC Sensor
- Front Fusebox Layout
- Cabin Fusebox Layout
- Aux Fusebox Layout
- E-Fuse Layout

HARNESS SYSTEM
- MX 12V System 1030412
- C – Center Console – 1032431
- D – FR LH Door – 1032432
- DT – FR LH Door Trim – 1036928
- F – Front Fascia – 1032433
- G – Rear Fascia – 1032435
- H – Main Body – 1032429
- J – IP – 1032436
- K – Roof – 1032437
- L – FEM – 1032438
- P – FR RH Door – 1032440
- PT – FR RH Door Trim – 1036928
- RL – RR LH Door Lower – 1032881
- RT – RR LH Door Trim – 1038205
- RU – RR LH Door Upper – 1032881
- SL – RR RH Door Lower – 1032442
- ST – RR RH Door Trim – 1038205
- SU – RR RH Door Upper – 1032882
- T – Liftgate – 1032443
- V – Overhead Console – 1052389
- W – Main Front – 1032447
- X – Rear Subframe – 1032448
- Power Distribution