Mazda RX-8 - Service Manual - Wiring Diagrams - Owners Manual - Parts Catalogue

MAZDA RX-8 - SERVICE MANUAL - WIRING DIAGRAMS - OWNERS MANUAL - PARTS CATALOGUE


- English Service Manual, Owners Manual Wiring Diagrams and Parts Catalogue, to cars Mazda RX-8.

 

CONTENTS:


01 SM INFO
- How To Use This Manual
- Service Cautions
- Identification Number Locations
- Scheduled Maintenance
- Pre-Delivery Inspection
- Jacking Positions, Vehicle Lift (2 Supports) And Safety Stand (Rigid Rack) Positions
- Tiedown Hook
- Towing
- Electrical System
- Sae Standards
- Abbreviations
- Units
- Installation Of Radio System
02 SM ENGINE PROBLEM
- Foreword
- Intermittent Concern Troubleshooting
- Engine Symptom Troubleshooting
- Quick Diagnostic Chart
- No.1 Melting Of Main Or Other Fuses
- No.2 Mil Comes On
- No.3 Will Not Crank
- No.4 Hard To Start/Long Crank/Erratic Start/Erratic Crank
- No.5 Engine Stalls-After Start/At Idle
- No.6 Cranks Normally But Will Not Start
- No.7 Slow Return To Idle
- No.8 Engine Runs Rough/Rolling Idle
- No.9 Fast Idle/Runs On
- No.10 Low Idle/Stalls During Deceleration
- No.11 Engine Stalls/Quits, Engine Runs Rough, Misses, Buck/Jerk, Hesitation/Stumble, Surges
- No.12 Lack/Loss Of Power-Acceleration/Cruise
- No.13 Knocking/Pinging/Detonation-Acceleration/Cruise
- No.14 Poor Fuel Economy
- No.15 Emission Compliance
- No.16 High Oil Consumption/Leakage
- No.17 Cooling System Concerns-Overheating
- No.18 Cooling System Concerns-Runs Cold
- No.19 Exhaust Smoke
- No.20 Fuel Odor (In Engine Compartment)
- No.21 Engine Noise
- No.22 Vibration Concerns (Engine)
- No.23 A/C Does Not Work Sufficiently
- No.24 A/C Is Always On Or A/C Compressor Runs Continuously
- No.25 A/C Does Not Cut Off Under Wide Open Throttle Conditions
- No.26 Exhaust Sulphur Smell
- No.27 Fuel Refill Concerns
- No.28 Fuel Filling Shut Off Issues
- No.29 Spark Plug Condition
- Inspection Procedures
03 SM ENGINE DETAILS
- Mechanical
- Mechanical
- Drive Belt
- Mechanical
- Rear Oil Seal
- Mechanical
- Lubrication System
- Oil Pressure
- Engine Oil
- Oil Filter
- Oil Cooler
- Oil Pan
- Metering Oil Pump
- Cooling System
- Engine Coolant
- Cooling System Cap
- Coolant Reserve Tank
- Radiator
- Thermostat
- Water Pump
- Cooling Fan
- Intake-Air System
- Air Cleaner
- Throttle Body
- Intake Manifold
- Variable Fresh Air Duct Solenoid Valve
- Variable Fresh Air Duct Actuator
- Secondary Shutter Valve Solenoid Valve
- Secondary Shutter Valve Actuator
- Variable Dynamic Effect Intake-Air Solenoid Valve
- Variable Dynamic Effect Intake-Air Actuator
- Auxiliary Port Valve Motor
- Check Valve
- Accelerator Pedal
- Fuel System
- Fuel Tank
- Nonreturn Valve
- Fuel Pump
- Fuel Injector
- Quick Connector
- Pulsation Damper
- Pressure Regulator
- Exhaust System
- Emission System
- Purge Solenoid Valve
- Catch Tank
- Air Filter (Emission System)
- Secondary Air Injection Control Valve
- Secondary Air Injection Solenoid Valve
- Secondary Air Injection Pump
- Charcoal Canister
- Evaporative Chamber
- Evap System Leak Detection Pump
- Rollover Valve
- Charging System
- Battery
- Generator
- Ignition System
- Ignition Coil
- Spark Plug
- High-Tension Lead
- Starting System
- Starter
- Starter Interlock Switch
- Cruise Control Switch
- Pcm Removal/Installation
- Pcm Configuration
- Neutral Switch
- Clutch Switch
- Metering Oil Pump
- Secondary Sutter Valve Switch
- Engine Coolant Temperature Sensor
- Intake Air Temperature Sensor
- Throttle Position Sensor
- Accelerator Pedal Position Sensor
- Auxiliary Port Valve Position Sensor
- Mass Air Flow Sensor
- Heated Oxygen Sensor
- Barometric Pressure Sensor
- Knock Sensor
- Eccentric Shaft Position Sensor
- Eccentric Shaft Position Plate
- Technical Data
04 SM ENGINE CONTROL
- On-Board Diagnostic (Engine Control System)
- Dtc P00xx
- Dtc P02xx
- Dtc P06xx
- Dtc P07xx
- Dtc P08xx
- Dtc P12xx
- Dtc P15xx
- Dtc P16xx
- Dtc P22xx
- Dtc P24xx
- Dtc P25xx
05 SM TRANSMISSIONS
- 05 Manualtransmission
- 06 Auto Transmission
06 SM DRIVETRAIN
- Propeller Shaft
- Drive Shaft
- Rear Drive Shaft
- Differential
- Differential (Ff/Fr)
- Differential Oil
- Differential Oil Seal
- Differential (Ff/Fr)
- Technical Data
- Driveline/Axle
07 SM BRAKES
- Conventional Brake System
- Brakes
- Conventional Brake System
- Vacuum Line
- Brake Pedal
- Brake Switch
- Master Cylinder
- Power Brake Unit
- Front Brake (Disc)
- Disc Pad (Front)
- Rear Brake (Disc)
- Disc Pad (Rear)
- Caliper (Rear)
- Antilock Brake System
- Dynamic Stability Control
- Parking Brake System
- Dsc Precaution
- Dsc Symptom Troubleshooting
- On-Board Diagnosis [Abs]  
- Dtc All [Abs]  
- On-Board Diagnosis [Dynamic Stability Control]
- Dtc All [Dynamic Stability Control]
- Troubleshooting All
- General Procedures (Brake)  
- Technical Data Brakes
08 SM STEERING
09 SM SUSPENSION
- Front Suspension
- Front Shock Absorber And Coil Spring
- Front Shock Absorber
- Front Upper Arm
- Front Lower Arm
- Front Stabilizer
- Stabilizer Control Link (Front/Rear)
- Front Crossmember
- Transverse Member
- Front Suspension Tower Bar
- Front Axle
- Front Axle
- Wheel Hub, Steering Knuckle
- Wheel Hub Bolt
- Rear Suspension
- Rear Shock Absorber And Coil Spring
- Rear Shock Absorber
- Rear Trailing Link
- Rear Lateral Link
- Toe Control Link
- Rear Stabilizer
- Stabilizer Control Link (Front/Rear)
- Rear Crossmember
- Rear Suspension
- Rear Axle
- Rear Axle
- Wheel Hub, Knuckle
- Wheel Alignment
- Suspension
- Front Suspension
- Standard Suspension
- Technical Data
10 SM HVAC
- Basic System
- Hvac Basic System
- Blower Unit
- Air Filter
- A/C Unit
- Evaporator
- Heater Core
- Airflow Mode Main Link
- Rear Heat Duct
- A/C Compressor
- Condenser
- Refrigerant Lines
- Air Intake Actuator
- Air Mix Actuator
- Airflow Mode Actuator
- Blower Motor
- Power
- Magnetic Clutch
- Ambient Temperature Sensor
- Evaporator Temperature Sensor
- Refrigerant Pressure Switch
- Climate Control Unit
- Fan Switch
- A/C Amplifier
- Refrigerant System
- Refrigerant System
- Refrigerant
- Technical Data
- Heater, Ventilation And Air Conditioning
- Troubleshooting Index
- No.1 Insufficient Air (Or No Air) Blown From Vents
- No.2 Amount Of Air Blown From Vents Does Not Change
- No.3 Air Intake Mode Does Not Change
- No.4 No Temperature Control With A/C Amplifier
- No.5 Windshield Fogged
- No.6 Air From Vents Cold Enough
- No.7 No Cool Air
- No.8 Noise While Operating A/C System
11 SM BODY
- 12 Body
- 13 Body Interior
12 SM SAFETY
- Air Bag System
- Foreword
- Flowchart
- Pid/Data Monitor Display
- Pid/Data Monitor Table
- Symptom Troubleshooting
- Air Bag System
- Air Bag System
- Air Bag System
- Driver-Side Air Bag Module
- Passenger-Side Air Bag Module
- Side Air Bag Module
- Curtain Air Bag Module
- Sas Control Module
- Crash Zone Sensor
- Side Air Bag Sensor
- Clock Spring
- Deployment Tool
- Air Bag Modules
- Seat Belt
- Seat Belt
- Front Seat Belt
- Rear Seat Belt
- Front Buckle
- Rear Buckle
- Seat Belt
- Child-Restrant Seat Anchor
13 SM ELECTRICAL
14 PARTS CATALOGUE
- Mazda 2004 Rx-8 Usa & Canada
- Part Numberindex
- Alphabetical Index
15 COLLISION CATALOGUE
16 AUTOMATIC TRANSMISSION 2004-2005 4 SPEED
- 1775-1u-03c(Index)
- 1775-1u-03c(00-00)
- 1775-1u-03c(05-13y)
- 1775-1u-03c(05-13z)
- 1775-1u-03c(05-50)
- 1775-1u-03c(05-60)
17 AUTOMATIC TRANSMISSION 2006 6 SPEED
18 MANUAL TRANSMISSION 2004-2008
- Contents
- Manual Transmission 05-11
- Technical Data 05-50
- Service Tools 05-60
19 MANUAL TRANSMISSION 2006
- 1848-1u-05f(Index)
- 1848-1u-05f(00-00)
- 1848-1u-05f(05-11)
- 1848-1u-05f(05-50)
- 1848-1u-05f(05-60)
20 ROTARY ENGINE 13B-MSP REPAIR MANUAL
- 1773-1u-03c(Cover)
- 1773-1u-03c(Index)
- 1773-1u-03c(00-00)
- 1773-1u-03c(01-10)
- 1773-1u-03c(01-50)
- 1773-1u-03c(01-60)
21 SERVICE HIGHLIGHTS 2004
- Contents
- General Information 00
- Engine 01
- Suspension 02
- Driveline / Axle 03
- Brakes 04
- Transmission / Transaxle 05
- Steering 06
- Hvac 07
- Restraints 08
- Body & Accessories 09
22 SERVICE HIGHLIGHTS 2006
- 3409-1u-05j(Index)
- 3409-1u-05j(00-00)
- 3409-1u-05j(01-00)
- 3409-1u-05j(01-02)
- 3409-1u-05j(01-13)
- 3409-1u-05j(05-00)
- 3409-1u-05j(05-02)
- 3409-1u-05j(05-13)
- 3409-1u-05j(05-14)
- 3409-1u-05j(08-00)
- 3409-1u-05j(08-02)
- 3409-1u-05j(08-10)
- 3409-1u-05j(09-00)
- 3409-1u-05j(09-14a)
- 3409-1u-05j(09-14b)
- 3409-1u-05j(09-20)
- 3409-1u-05j(09-22)
23 WIRING DIAGRAMS (FE1031)
- Warning
- Contents
- System Index
- General Information
- Y Ground Point
- W Electrical Wiring Schematic
- A Charging System / Starting System
- B-1 Engine Control System
- B-2 Fuel Control System
- B-3 Cooling Fan System
- C Instrument Cluster
- D Windshield Wiper And Washer
- E-1-E-2 Headlight
- E-3 Front Fog Light
- E-4 License Plate Light / Parking Light / Side Marker Light / Taillight
- E-5 Headlight Auto Leveling System
- E-6 Headlight Cleaner System
- F-1 Turn And Hazard Warning Light
- F-2 Back- Up Light
- F-3 Brake Light / High- Mount Brake Light / Horn
- G-1 Heater And Air Conditioner
- G-2 Magnetic Clutch Control System
- H Ec-At Control System
- I-1 Rear Window Defroster / Trunk Compartment Light
- I-2 Illumination Light
- I-3 Courtesy Light / Ground Illumination Light / Interior Light / Map Light / Vanity Mirror Illumination
- I-4 Acc Relay / Cigarette Lighter
- J-1-J-2 Audio System
- K-1 Power Window System
- K-2 Keyless Unit
- L Heated Outer Mirror / Power Outer Mirror
- M Sliding Sunroof
- N Electric Power Steering (Eps) System
- O Dynamic Stability Control (Dsc) System
- P-1 Power Seat
- P-2 Seat Warmer
- S Air Bag System Service Cautions / Service Warnings
- S-1 Air Bag System
- T-1 Immobilizer System
- T-2 Accessory Socket / Trunk Lid Opener
- U Data Link Connector
- X Common Connector List
- Alphabetical Index
24 WIRING DIAGRAMS (FE1032)
- Warning
- Contents
- System Index
- General Information
- Y Ground Point
- W Electrical Wiring Schematic
- A Charging System / Starting System
- B-1 Engine Control System
- B-2 Fuel Control System
- B-3 Cooling Fan System
- C Instrument Cluster
- C-2 Information Display
- D Windshield Wiper And Washer
- E-1-E-2 Headlight
- E-3 Headlight Cleaner System
- E-4 Front Fog Light
- E-5 Rear Fog Light
- E-6 License Plate Light / Parking Light / Taillight
- E-7 Headlight Auto Leveling System
- E-8 Auto Light Control System
- F-1 Turn And Hazard Warning Light
- F-2 Back-Up Light
- F-3 Brake Light / High-Mount Brake Light / Horn
- G-1 Heater And Air Conditioner
- G-2 Magnetic Clutch Control System
- H Automatic Transmission Control System
- I-1 Rear Window Defroster / Trunk Compartment Light
- I-2 Illumination Light
- I-3 Courtesy Light / Ground Illumination Light / Interior Light / Map Light / Vanity Mirror Illumination
- I-4 Acc Relay / Cigarette Lighter
- J-1 Audio System
- J-3 Car-Navigation System
- K-1 Power Window System
- K-2 Keyless Unit
- L Heated Outer Mirror / Power Outer Mirror
- M Sliding Sunroof
- N Electric Power Steering(Eps)System
- O Dynamic Stability Control(Dsc)System
- P-1 Power Seat
- P-2 Seat Warmer
- S-1 Air Bag System
- T-1 Immobilizer System
- T-2 Accessory Socket / Trunk Lid Opener
- U Data Link Connector
- X Common Connector List
- Alphabetical Index
25 OWNERS MANUAL 2004
- Contents
- 1. Vehicle At A Glance
- 2. Essential Safety Equipment
- 3. Knowing Your Mazda
- 4. Before Driving Your Mazda
- 5. Driving Your Mazda
- 6. Interior Comfort
- 7. In Case Of Emergency
- 8. Maintenance & Care
- 9. Customer Information And Reporting Safety Defects
- 10. Specifications
- Index
- Navigation System
- Back To 2004 Rx8 Manual Index
26 OWNERS MANUAL 2005
- 0. #Introduction#
- Table Of Contents
- 1. Your Vehicle At A Glance
- 2. Essential Safety Equipment
- 3. Knowing Your Mazda
- 4. Before Driving Your Mazda
- 5. Driving Your Mazda
- 6. Interior Comfort
- 7. In Case Of An Emergency
- 8. Maintenance And Care
- 9. Customer Information And Reporting Safety Defects
- 10. #Specifications#
- 11. #Index#
27 OWNERS MANUAL 2006
- 0. #Introduction#
- Table Of Contents
- 1. Your Vehicle At A Glance
- 2. Essential Safety Equipment
- 3. Knowing Your Mazda
- 4. Before Driving Your Mazda
- 5. Driving Your Mazda
- 6. Interior Comfort
- 7. In Case Of An Emergency
- 8. Maintenance And Care
- 9. Customer Information And Reporting Safety Defects
- 10. #Specifications#
- 11. #Index#
28 OWNERS MANUAL 2007
- Rx-8_8v89-Ea-06f_Edition1