Arctic Cat 366 (2008-2011) - Workshop Manual / Repair Manual

ARCTIC CAT 366 (2008-2011) - SERVICE MANUAL / REPAIR MANUAL

- English Workshop Manual / Repair Manual for quad Arctic Cat 366 (2008-2011).
 

INDEX:

GENERAL INFORMATION
- General Specifications
- Torque Specifications
- Torque Conversions (ft-lb/N-m)
- Break-In Procedure
- Gasoline - Oil - Lubricant
- Genuine Parts
- Preparation For Storage
- Preparation After Storage

PERIODIC MAINTENANCE
- SPECIAL TOOLS
- Periodic Maintenance Chart
- Lubrication Points
- Air Filter
- Valve/Tappet Clearance
- Testing Engine Compression
- Spark Plug
- Muffler/Spark Arrester
- Adjusting Throttle Cable
- Adjusting Engine RPM (Idle)
- Engine/Transmission Oil - Filter - Strainer
- Front Differential/Rear Drive Lubricant
- Tires
- Driveshaft/Coupling
- Nuts/Bolts/Cap Screws
- Ignition Timing
- Lights
- Shift Lever
- Frame/Welds/Racks
- Hydraulic Brake Systems
- Burnishing Brake Pads
- Checking/Replacing V- Belt

ENGINE/TRANSMISSION
- SPECIAL TOOLS
- Specifications
- Troubleshooting
- Removing Engine/ Transmission
- Top-Side Components
- Removing Top-Side Components
- Servicing Top-Side Components
- Installing Top-Side Components
- Left-Side Components
- Removing Left-Side Components
- Installing Left-Side Components
- Right-Side Components
- Removing Right-Side Components
- Servicing Right-Side Components
- Installing Right-Side Components
- Center Crankcase Components
- Separating Crankcase Halves
- Disassembling Crankcase Half
- Servicing Center Crankcase Components
- Joining Crankcase Halves
- Assembling Crankcase Half
- Installing Engine/ Transmission

FUEL/LUBRICATION/COOLING
- SPECIAL TOOLS
- Carburetor Specifications
- Electric Choke
- Carburetor
- Throttle Cable Free-Play
- Engine RPM (Idle)
- Gas Tank
- Oil Filter/Oil Pump
- Testing Oil Pump Pressure
- Oil Cooler
- Troubleshooting

ELECTRICAL SYSTEM
- SPECIAL TOOLS
- Specifications
- Electrical Connections
- Battery
- RPM Limiter
- Testing Electrical Components
- Accessory Receptacle/ Connector
- Brakelight Switch (Pressure)
- Oil Temperature and Cooling Fan Switches
- Fan Motor
- Fuse Block/Power Distribution Module
- Ignition Coil
- Speed Sensor
- Ignition Switch
- Handlebar Control Switches
- Front Drive Selector Switch
- Front Drive Selector Actuator
- Gear Position Switch
- Stator Coil
- Starter Relay
- Starter Motor
- CDI Unit
- Regulator/Rectifier
- Lights
- Ignition Timing
- Troubleshooting

DRIVE SYSTEM
- GENERAL INFORMATION
- SPECIAL TOOLS
- Front Drive Actuator
- Front Differential
- Drive Axles
- Rear Gear Case
- Hub
- Hydraulic Brake Caliper
- Troubleshooting Drive System
- Troubleshooting Brake System

SUSPENSION
- Shock Absorbers
- Front A-Arms
- Rear A-Arms
- Wheels and Tires
- Troubleshooting

STEERING/FRAME
- Steering Post/Tie Rods
- Handlebar Grip
- Steering Knuckles
- Measuring/Adjusting Toe- Out
- Front Rack
- Front Bumper Assembly
- Front Body Panel/Fender
- Exhaust System
- Rear Body Panel/Rack
- Seat
- Troubleshooting

CONTROLS/INDICATORS
- Hand Brake Lever/Master Cylinder Assembly
- Throttle Control
- LCD Gauge