Arctic Cat HDX Crew (2017) - Workshop Manual, User Manual, Parts Catalogue

ARCTIC CAT HDX CREW (2017) - SERVICE MANUAL - OWNERS - SPARE PARTS CATALOGUE

- English Workshop Manual, User Manual and Parts Catalogue for UTV Arctic Cat HDX Crew (2017).


INDEX:


SERVICE MANUAL

- GENERAL INFORMATION/ FOREWORD
- Specifications
- Torque Specifications
- Torque Conversions (Ft-Lb/ N-M)
- Gasoline - Oil - Lubricant
- Preparation For Storage
- Preparation After Storage

- PERIODIC MAINTENANCE/ TUNE-UP
- Special Tools
- Air Inlet Pre-Filter
- Air Filter
- Valve/Tappet Clearance
- Testing Engine Compression
- Spark Plug
- Muffler/Spark Arrester
- Engine/Transmission Oil - Filter
- Front Differential - Rear Drive Lubricant
- Driveshaft/Coupling
- Headlight - Taillight/ Brakelight
- Shift Cable
- Hydraulic Brake System
- Burnishing Brake Pads
- Checking/Replacing V-Belt

- STEERING/BODY/CONTROLS
- Steering Wheel
- Steering System
- Steering Knuckles
- Accelerator Pedal
- Shift Lever
- Shift Cable
- Lcd Gauge
- Front Wheel Alignment
- Front Fascia/Front Bumper
- Hood
- Front Fenders
- Floor
- Side Restraint Latches
- Dashboard
- Belly Panel
- Muffler
- Cargo Box
- Taillight Assembly
- Seat
- Seat Backs
- Troubleshooting

- ENGINE/TRANSMISSION
- Special Tools
- Troubleshooting
- Removing Engine/ Transmission
- Installing Engine/ Transmission
- Servicing Engine
- Removing Top-Side Components
- Servicing Top-Side Components
- Installing Top-Side Components
- Removing Left-Side Components
- Servicing Left-Side Components
- Installing Left-Side Components
- Removing Right-Side Components
- Servicing Right-Side Components
- Installing Right-Side Components
- Center Crankcase Components
- Separating Crankcase Halves
- Disassembling Crankcase Half
- Servicing Center Crankcase Components
- Assembling Crankcase Half
- Joining Crankcase Halves

- FUEL/LUBRICATION/ COOLING
- Troubleshooting
- Special Tools
- Throttle Body
- Gas Tank
- Oil Pump
- Liquid Cooling System
- Troubleshooting

- ELECTRICAL SYSTEM
- Testing Electrical Components
- Special Tools
- Battery
- Electronic Power Steering (Eps)
- Ignition Switch
- Ignition Coil
- Ignition Timing
- Accessory Receptacle/ Connector
- Switches
- Fan Motor
- Lights
- Power Distribution Module (Pdm)
- Efi Sensors/Components
- Rpm Limiter
- Stator Coil
- Regulator/Rectifier
- Starter Motor
- Starter Relay
- Electronic Control Module (Ecm)
- Efi Diagnostic System
- Troubleshooting

- DRIVE SYSTEM
- General Information
- Special Tools
- Front Drive Actuator
- Front Differential
- Center/Front Propeller Shaft/Carrier Bearing Assembly
- Drive Axles
- Rear Gear Case
- Hub
- Hydraulic Brake Caliper
- Troubleshooting Drive System
- Troubleshooting Brake System

- SUSPENSION
- Special Tool
- Shock Absorbers
- Front A-Arms
- Rear A-Arms
- Wheels And Tires
- Troubleshooting


PARTS CATALOGUE

- INTERNATIONAL GREEN

- accelerator assembly [301534]
- air intake assembly [301536]
- battery and starter motor assembly [301544]
- cam chain assembly [300730]
- cargo box and tailgate assembly [301548]
- case/belt cooling assembly [301539]
- clutch/v-belt/magneto cover assembly [301480]
- console and floor panel assembly [301527]
- cooling assembly [301538]
- crank balancer assembly [94435]
- crankcase assembly [301477]
- crankshaft and piston assembly [300125]
- cylinder assembly [300238]
- cylinder head and camshaft/valve assembly [301476]
- dash assembly [301532]
- drive train assembly [301540]
- engine and exhaust [301537]
- frame and related parts [301528]
- front and rear brake assembly [301533]
- front drive gearcase assembly [301541]
- front suspension assembly [300715]
- gas tank assembly [300977]
- gear shifting assembly [300127]
- grill and headlight assembly [301269]
- hood/front storage and side panel assembly [301526]
- magneto assembly [300128]
- oil filter/pump assembly [99739]
- rear drive gearcase assembly [301542]
- rear suspension assembly [300975]
- rops and taillight assembly [301531]
- seat assembly [301530]
- secondary drive assembly [301545]
- secondary transmission assembly [300083]
- shifter assembly [301535]
- starter clutch assembly [300126]
- steering assembly [300738]
- sway bar assembly [94120]
- throttle body assembly [90590]
- tilt frame assembly [300971]
- transmission assembly [300242]
- water pump assembly [90695]
- wheel and tire assembly [301311]
- wiring harness assembly [301543


- INTERNATIONAL RED

- accelerator assembly [301534]
- air intake assembly [301536]
- battery and starter motor assembly [301544]
- cam chain assembly [300730]
- cargo box and tailgate assembly [301529]
- case/belt cooling assembly [301539]
- clutch/v-belt/magneto cover assembly [301480]
- console and floor panel assembly [301527]
- cooling assembly [301538]
- crank balancer assembly [94435]
- crankcase assembly [301477]
- crankshaft and piston assembly [300125]
- cylinder assembly [300238]
- cylinder head and camshaft/valve assembly [301476]
- dash assembly [301532]
- drive train assembly [301540]
- engine and exhaust [301537]
- frame and related parts [301528]
- front and rear brake assembly [301533]
- front drive gearcase assembly [301541]
- front suspension assembly [300715]
- gas tank assembly [300977]
- gear shifting assembly [300127]
- grill and headlight assembly [301269]
- hood/front storage and side panel assembly [301547]
- magneto assembly [300128]
- oil filter/pump assembly [99739]
- rear drive gearcase assembly [301542]
- rear suspension assembly [300975]
- rops and taillight assembly [301531]
- seat assembly [301530]
- secondary drive assembly [301545]
- secondary transmission assembly [300083]
- shifter assembly [301535]
- starter clutch assembly [300126]
- steering assembly [300738]
- sway bar assembly [94120]
- throttle body assembly [90590]
- tilt frame assembly [300971]
- transmission assembly [300242]
- water pump assembly [90695]
- wheel and tire assembly [301311]
- wiring harness assembly [301543


- INTERNATIONAL CAMO

- accelerator assembly [301534]
- air intake assembly [301536]
- battery and starter motor assembly [301544]
- cam chain assembly [300730]
- cargo box and tailgate assembly [301549]
- case/belt cooling assembly [301539]
- clutch/v-belt/magneto cover assembly [301480]
- console and floor panel assembly [301527]
- cooling assembly [301538]
- crank balancer assembly [94435]
- crankcase assembly [301477]
- crankshaft and piston assembly [300125]
- cylinder assembly [300238]
- cylinder head and camshaft/valve assembly [301476]
- dash assembly [301532]
- drive train assembly [301540]
- engine and exhaust [301537]
- frame and related parts [301528]
- front and rear brake assembly [301533]
- front drive gearcase assembly [301541]
- front suspension assembly [301550]
- gas tank assembly [300977]
- gear shifting assembly [300127]
- grill and headlight assembly [301269]
- hood/front storage and side panel assembly [300987]
- magneto assembly [300128]
- oil filter/pump assembly [99739]
- rear drive gearcase assembly [301542]
- rear suspension assembly [300975]
- rops and taillight assembly [301531]
- seat assembly [301530]
- secondary drive assembly [301545]
- secondary transmission assembly [300083]
- shifter assembly [301535]
- starter clutch assembly [300126]
- steering assembly [300738]
- sway bar assembly [94120]
- throttle body assembly [90590]
- tilt frame assembly [300971]
- transmission assembly [300242]
- water pump assembly [90695]
- wheel and tire assembly [301546]
- wiring harness assembly [301543


OWNERS MANUAL

- Front Cover
- This Vehicle Can Be Hazardous To Operate.
- free rov training
- Foreword
- protect your sport
- Table Of Contents
- division i - safety
- division ii - operation/ maintenance
- Division I - Safety
- This Vehicle Is Not A Toy And Can Be Hazardous To Operate.
- Safety Alert
- to avoid serious injury or death:
- Hangtag
- Warning Labels
- Warning Labels
- Location Of Parts And Controls
- Warnings
- never operate up or down hills steeper than 15°
- Division Ii - Operation/ Maintenance
- Specifications
- Vehicle Operation
- pre-start/pre-operation checklist
- Vehicle Operation
- starting the vehicle
- shifting
- driving the vehicle
- braking/stopping
- parking
- basic turns
- driving uphill
- never operate up or down hills steeper than 15°
- driving downhill
- crossing obstacles
- driving in reverse
- skidding or sliding
- crossing water
- crossing roads
- control locations and functions
- occupant side restraints
- cargo box
- power steering
- speedometer/lcd (digital)
- oil level stick
- load capacity ratings chart
- trailering and towing
- transporting
- gasoline-oil-lubricant
- engine break-in
- burnishing brake pads
- liquid cooling system
- oil cooler
- shock absorbers
- general lubrication
- hydraulic brake
- gas hoses
- protective rubber boots
- battery
- spark plug
- air inlet pre-filter
- air filter/housing drain
- draining v-belt cover
- tires
- wheels
- muffler/spark arrester
- light bulb replacement
- checking/adjusting headlight aim
- fuses
- electrical output terminals
- storage compartment/ tools
- seat belts
- occupant side restraints
- rops
- Maintenance Record
- Identification Numbers Record
- 1. key identification number:
- 2. vehicle identification number:
- 3. engine serial number:
- Back Cover